1999 Powerstroke Problems
#21
Ok guys i need answers now yeasterday it cuts out so often now and dies going down the highway it idles so ******* bad just a low grumble and when i hold the pedal in a constant spot it will reve up on its own and slow down on its own. I wish you could tell me whats wrong. Im afraid something is going to break because of the way it jerks on the highway i mean its just Boom like the breaks get slamed on. help now if you can tell me what it is
#22
has the HPOP ever been replaced? I said a couple posts ago that this kinda sounds like a weak oil system or a possibly failing IDM or IPR. Can you get a scanner on it?
---AutoMerged DoublePost---
it would really help if we could see what your IPR % is with key on engine off, at idle, and going down the highway when it's doing it. I would also like to see what your fuel pressure is, along with your ICP (injection control pressure).
Has the IDM ever been messed with or opened to check for moisture?
---AutoMerged DoublePost---
when the truck starts to bog and slow down "like the brakes get slammed on", do you hear a whooshing noise from the exhaust or under the floor? And has the EBP sensor (exhaust back pressure) ever been replaced?
---AutoMerged DoublePost---
it would really help if we could see what your IPR % is with key on engine off, at idle, and going down the highway when it's doing it. I would also like to see what your fuel pressure is, along with your ICP (injection control pressure).
Has the IDM ever been messed with or opened to check for moisture?
---AutoMerged DoublePost---
when the truck starts to bog and slow down "like the brakes get slammed on", do you hear a whooshing noise from the exhaust or under the floor? And has the EBP sensor (exhaust back pressure) ever been replaced?
Last edited by DieselDanBoy; 02-10-2012 at 11:16 AM. Reason: Automerged Doublepost
#23
#24
well what's the temp outside? 7.3's are a cold bitch, if they sit and idle long enough for coolant temp to drop below a certain point (i dont know what the limit is), they'll kick up in high idle to get back up to temp, my fathers excursion will do the same thing even after running for 4 HOURS.
any info on anything with the high pressure oil system? Or codes?
any info on anything with the high pressure oil system? Or codes?
#25
#26
#27
ok another update well i took it to my local diesel shop and they replaced the oil pressure sensor or something and that fixed the idle problems. and idling and dieing frequently. but it still dies when i turn the wipers on delay. My diesel shop ordered me a new wiper motor do i need it?
Well, your wiper motor does use quite a bit of amperage. Unless it has an internal short (which should pop a fuse) or its drawing an INSANE amount of current (which should still pop a main fuse), and the motor is working fine, i DO NOT think it's a motor. I think it's more likely something to do with the multifunction switch that controls your wipers and signals. Those cause a bunch of wacky issues.
---AutoMerged DoublePost---
can you give me what options the truck has (power locks, windows, etc...)? I'm going to look up a wiring schematic and dig a little bit
From what I'm seeing, there's a run/park relay for the wiper motor inside the multifunction switch that is hot in accessory or run.
Last edited by DieselDanBoy; 02-18-2012 at 12:51 PM. Reason: Automerged Doublepost
#28
power lock power windows uhhh its an XLT that should tell you everything.
---AutoMerged DoublePost---
also with the multifunction switch what do i need to do with it like have it tested or replaced and yes it was the ICP.
---AutoMerged DoublePost---
also with the multifunction switch what do i need to do with it like have it tested or replaced and yes it was the ICP.
Last edited by PowerStrokeToTheEnd; 02-18-2012 at 03:52 PM. Reason: Automerged Doublepost
#30