AC Problem
#1
AC Problem
I seem to be having an intermittent problem with the clutch in the AC system. When I turn off the engine (ignition key in OFF position) the clutch stays energized. I didn't notice it the first time and it drained both batteries dead. While re-installing the batteries after charging them I noticed a clicking. Found the magnetic clutch was engaging. I removed the connector on top of the AC compressor, finished connecting the batteries, and started the engine. Everything was fine except the AC clutch is staying energized even though I have the AC (and defrost) turned off. Is there a relay someplace in the circuity that might be getting stuck? Any ideas? Thanks.
#4
#5
if you recharge it sometimes you can put too much in and it will constantly spin the clutch wether its on or off
notice when you charged it the compressor would spin and stop. spin and stop, untill it was full and just constantly spin? if it is too much pressure it will make it spin
sounds stupid but ive seen it happen HVAC is a pain.
ALTHOUGH if there is a relay, you can see it works by taking the cap off and pushing the relay to the spool. if it spins the AC only when you touch it, its not the relay
notice when you charged it the compressor would spin and stop. spin and stop, untill it was full and just constantly spin? if it is too much pressure it will make it spin
sounds stupid but ive seen it happen HVAC is a pain.
ALTHOUGH if there is a relay, you can see it works by taking the cap off and pushing the relay to the spool. if it spins the AC only when you touch it, its not the relay
#6
Thread
Thread Starter
Forum
Replies
Last Post
burndiesel
24 Valve 2nd Gen Dodge Cummins 98.5-02
10
02-07-2023 01:15 AM
jeremy01995
12 Valve 2nd Gen Dodge Cummins 94-98
1
09-14-2015 06:34 PM
thurobred1320
12 Valve 2nd Gen Dodge Cummins 94-98
2
05-05-2015 09:26 PM