no throttle sometimes?
#1
no throttle sometimes?
this is my second 6.0 should of learned my lesson first time! right? every once in a while I go to take off and when i press on the throttle the idle doesnt pickup, then it will start to rev after a few seconds and it usually blows alot of smoke. it only happens maybe once a week truck has 85000 miles and is all stock any ideas? please help my local dealer likes to just experiment with changing parts and slapping u with a huge bill. thanks
#3
This hesitation could be several things.
Your EBP sensor may be bad or erratic. Should see codes P2263 or P0299 if the exhaust backpressure sensor is faulty. This should also exhibit buck/jerk, hesitation, lack of power, stalling, stumble, black smoke, surging, rolling idle, changes in engine sound at idle or when driving at a steady speed. This sensors signal reading should be .88 - .9 volts at sea level and decrease by .1 volt for every 2000 feet above sea level. Check with the key ON but engine OFF.
This may be low boost caused by the turbo not spooling up as you move the throttle.
The variable vanes may be coked up and sticking from time to time. Remove turbo and clean it up yourself.
Can you hear the turbo whistle as you step on the throttle when its acting up?
Check all of your intercooler hoses before the turbo for leaks.
Your EBP sensor may be bad or erratic. Should see codes P2263 or P0299 if the exhaust backpressure sensor is faulty. This should also exhibit buck/jerk, hesitation, lack of power, stalling, stumble, black smoke, surging, rolling idle, changes in engine sound at idle or when driving at a steady speed. This sensors signal reading should be .88 - .9 volts at sea level and decrease by .1 volt for every 2000 feet above sea level. Check with the key ON but engine OFF.
This may be low boost caused by the turbo not spooling up as you move the throttle.
The variable vanes may be coked up and sticking from time to time. Remove turbo and clean it up yourself.
Can you hear the turbo whistle as you step on the throttle when its acting up?
Check all of your intercooler hoses before the turbo for leaks.
#4
update
i cleaned my egr valve yesterday it was pretty sooted up but dry. put it back in and the truck ran worse valve was stuck partially open and after i cleaned it moved back to closed position still have no engine light on. I unplugged egr while it was running and the problem cleared up so looks like I will be going with an egr delete asap. thanks for all the help
#6
Thread
Thread Starter
Forum
Replies
Last Post
12vWoodHauler
12 Valve 2nd Gen Dodge Cummins 94-98
1
09-30-2015 07:58 PM
Jake202
Chevy/GMC 6.2L and 6.5L
7
06-21-2015 09:42 PM
1stgenswap
1st Generation Dodge Cummins 89-93
2
11-03-2014 09:45 PM