EGR Block-Off Kit - 6.0L Power Stroke
#11
#12
you have to be careful when you screw with the egr system, because it is also part of crankcase vent. if it is insf. the oil drain in turbo will not drain and will overfill , because it is being serviced with 70lbs of oil pressure. when it doesnt drain it will cause oil out the back of turbo , so black smoke in exhaust , oil out the front of turbo will fill your cylinders and intercooler with oil. best case you will lose compression ,worst case the oil mixes with fuel being supplied normally and you could go virial and it may self destruct. it almost happen to me. luckily i stopped as soon as i got the smoke. all im saying in effort to elim. one prob you dont create another. ecodiesel. does anyone bypass egr and not get ck engine lite? and cc venting
another thing oil will not, i repeat, will not cause black smoke out of the exhauts. only way to get black smoke is have more fuel than you have air to burn it.
the oil in the turbo, intercooler and tubes is from the CCV that is in the plumbed into the stock intake.
the oil from the CCV gets burned in the cylinder. it causes no problems with the internals of the motor. but it has been known to blow IC boots off.
i have done 4 egr deletes. each truck the turbo spooled alot faster. and also gained 2 mpg just by doing the delete.
#13
Thread
Thread Starter
Forum
Replies
Last Post
Diesel Bombers
General Diesel Related
0
09-21-2015 08:00 AM
Diesel Bombers
General Diesel Related
0
12-10-2014 08:10 AM
Diesel Bombers
General Diesel Related
0
10-13-2014 08:10 AM