1996 International 4700 with 7.3 T444e
#1
1996 International 4700 with 7.3 T444e
Installed two new batteries, engine will not crank. Gauges sweep, buzzer buzzes with key OFF. Positive cable to started solenoid. Negative cable to grounded battery box and front of starter. Probed solenoid, voltage there, did not jump solenoid. What have I done wrong? Any ideas and a starter circuit diagram. Thanks. An understatement to be sure. LOL.
#2
Does the starter solenoid click at all? That is the first thing I check. If it does not, use a remote start switch on it to see if it does physically work. I've installed 2 in 2 of my trucks in the last 6 months. Both went bad from both sitting idle(?) Is also the same relay as the GPR.
If it does, but still nothing while using the ignition switch, check the fusible links at that same solenoid and the maxi-fuses in the aux power box. There are 3 maxi-fuses that supply power to the ignition switch.
If it does with the switch, but nothing from the starter, check the voltage from the Starter solenoid to the starter when activated. If none, replace that solenoid. If there is, pull the starter and have it tested. When I replace mine or a friend's, I buy lifetime warrantied starters. As long as these run, that is a long lifetime.
If it does, but still nothing while using the ignition switch, check the fusible links at that same solenoid and the maxi-fuses in the aux power box. There are 3 maxi-fuses that supply power to the ignition switch.
If it does with the switch, but nothing from the starter, check the voltage from the Starter solenoid to the starter when activated. If none, replace that solenoid. If there is, pull the starter and have it tested. When I replace mine or a friend's, I buy lifetime warrantied starters. As long as these run, that is a long lifetime.
Last edited by MAFoElffen; 04-04-2014 at 04:31 AM.
The following users liked this post:
QobiYashi (04-09-2014)
#3
Thread
Thread Starter
Forum
Replies
Last Post
krinderhagen
Ford 83-94 6.9 and 7.3L General
5
01-15-2015 12:07 AM
krinderhagen
Ford 83-94 6.9 and 7.3L General
0
12-31-2014 07:12 PM
UniqueCopy
Ford Powerstroke 94-98 7.3L
2
12-14-2014 11:37 AM