2005 engine rebuild wont start
#1
2005 engine rebuild wont start
I just rebuilt the motor, also put new injectors in. Won’t start. When I turn the key on the lift pump relay turns on and off and the lift pump runs constant. Also can’t get edge insight gauge set to install or cannot get scan tool to work. Any ideas would be great.
---AutoMerged DoublePost---
tried unplugging and reconnecting the connectors, did not help. The fuel pump relay just goes click click click constantly, also the cp3 pump is clicking, if i dissconnect the plug on the cp3 pump then the feul realy clicks at half the rate. Is this by chance how it purges the air? If so do i possiably have a leaking connector tube? But this still does not answer why i can not connect insite guage or scan tool.
---AutoMerged DoublePost---
tried unplugging and reconnecting the connectors, did not help. The fuel pump relay just goes click click click constantly, also the cp3 pump is clicking, if i dissconnect the plug on the cp3 pump then the feul realy clicks at half the rate. Is this by chance how it purges the air? If so do i possiably have a leaking connector tube? But this still does not answer why i can not connect insite guage or scan tool.
Last edited by 2005DFS; 12-17-2012 at 03:44 PM. Reason: Automerged Doublepost
#3
solved the problem, had a ground wire in wrong place. But now i have a new problem truck starts and runs fine, however when it idles i loose oil pressure get error code P0524, not sure if it is the sensor, or another issue, i will have to get a manual guage and check it off the top of oil filter.
Last edited by 2005DFS; 12-17-2012 at 09:20 PM.
#6
2005DFS, What and where was your grounding issue? Im having the same issue after a rebuild LP relay just click constantly and The truck wont start. I installed a FASS and just wired a switch and relay in the cab. Im getting fuel at the cp3 and the rail but no start. Bad FCA? any help is great!
Merry Christmas, Chris
Merry Christmas, Chris
#7
Thread
Thread Starter
Forum
Replies
Last Post
burndiesel
24 Valve 2nd Gen Dodge Cummins 98.5-02
10
02-07-2023 01:15 AM
Cavnar
Diesel In Distress - Support Ticket
3
09-09-2015 07:18 PM
mcclusk
24 Valve 2nd Gen Dodge Cummins 98.5-02
3
02-21-2015 09:50 PM