12 Valve 2nd Gen Dodge Cummins 94-98 Discussion of 12 Valve 5.9 Liter Dodge Cummins Diesels with P7100 Injection Pumps

Electrical problem

Thread Tools
 
Search this Thread
 
  #1  
Old 11-18-2015, 08:50 PM
casper83's Avatar
Diesel Fan
Thread Starter
Join Date: Oct 2009
Location: lebanon tennessee
Posts: 97
Likes: 0
Received 3 Likes on 3 Posts
Default Electrical problem

I have a 96 12 valve and my tach doesn't work, no charging system, and the transmission won't shift out of second gear. I have been told that the pcm is bad. I have read that the pcm is also the most unnecessary replacement on that year model. I have also read that my crank sensor could be bad. Is there any tests I can do to make sure I don't have to fork over. 400 bucks for a pcm for nothing. Thanks in advance.
 
  #2  
Old 11-19-2015, 04:12 AM
Jet A Fuel's Avatar
Diesel Bomber
Join Date: Aug 2009
Location: Georgia
Posts: 1,981
Received 347 Likes on 309 Posts
Default

If your voltage is below 12 volts the PCM won't work but here are a few checks and some ideas.

To check the PCM do This : disconnect your crank sensor, turn the key on, check the harness side Blk/Lt Blu wire for ground (low Resistance). Check PPL/Wht wire for 5 volts DC. If these check good chances are your PCM is fine.
To check the sensor do this; check resistance at Crank sensor pig tail (Unplugged still) between PPL/WHT and Blk/LT Blu should be some resistance showing and not a open circuit.

Here are some schematics to help you out.

1996 engine schematic1.pdf

1996 engine schematic2.pdf

1996 engine schematic3.pdf
 

Last edited by Jet A Fuel; 11-19-2015 at 04:14 AM.
  #3  
Old 11-19-2015, 05:12 AM
casper83's Avatar
Diesel Fan
Thread Starter
Join Date: Oct 2009
Location: lebanon tennessee
Posts: 97
Likes: 0
Received 3 Likes on 3 Posts
Default

Thanks for the reply. I'll have to try that out this afternoon when I get in from work. I'll repost after.
 
  #4  
Old 11-28-2015, 08:18 PM
casper83's Avatar
Diesel Fan
Thread Starter
Join Date: Oct 2009
Location: lebanon tennessee
Posts: 97
Likes: 0
Received 3 Likes on 3 Posts
Default

I found my problem right off the bat! The plug for the crank sensor had vibrated loose. However, now I can drive it, but when I go to stop, my transmission won't shift itself out of gear. I have to shift it into neutral and then back in drive. I pulled the pcm out at one point. Could that have caused it? At one time there was a lockup switch on the truck but everything has been disconnected. TIA
 
  #5  
Old 12-07-2015, 03:54 PM
casper83's Avatar
Diesel Fan
Thread Starter
Join Date: Oct 2009
Location: lebanon tennessee
Posts: 97
Likes: 0
Received 3 Likes on 3 Posts
Default

Anybody?
 




All times are GMT -5. The time now is 01:40 PM.