NV4500 Troubles
#1
NV4500 Troubles
Well I think something is headed south in my trans. I went a little over a week ago to the Simpson County KY pull and won the 2500/SRW 3500 class.
Next week trans starts making noise 1/2 way to work or home (little less than 20 miles). Sounds like something smacking up against the shifter at first...but I checked the floor and nothings rubbing anywhere...sounds like its come from the trans. Well once the trans gets good and hot....almost before I get to work or all the way home it starts making a binding noise? :confused:
Today I pulled the PTO covers on both sides and spun the drive-line to check for any damaged gears. I could not see any damage at all?!
Well after calling Cousin Billy @ BRC Diesel I decided to pull the driveshaft and check the snap ring on the back of the Transfer case. Well...the snap ring was fine...but I over stretched/bent it trying to put it back on. So now my truck has gone from making noise's to being down till I can get another snap ring on Monday.
Anybody had any experience like this? I know its hard to diagnose from just trying to explain it, but I'm hoping somebody has some suggetions of any time. Right now.....its not looking good.
Next week trans starts making noise 1/2 way to work or home (little less than 20 miles). Sounds like something smacking up against the shifter at first...but I checked the floor and nothings rubbing anywhere...sounds like its come from the trans. Well once the trans gets good and hot....almost before I get to work or all the way home it starts making a binding noise? :confused:
Today I pulled the PTO covers on both sides and spun the drive-line to check for any damaged gears. I could not see any damage at all?!
Well after calling Cousin Billy @ BRC Diesel I decided to pull the driveshaft and check the snap ring on the back of the Transfer case. Well...the snap ring was fine...but I over stretched/bent it trying to put it back on. So now my truck has gone from making noise's to being down till I can get another snap ring on Monday.
Anybody had any experience like this? I know its hard to diagnose from just trying to explain it, but I'm hoping somebody has some suggetions of any time. Right now.....its not looking good.
#2
Thread
Thread Starter
Forum
Replies
Last Post
Robert hawkins
24 Valve 2nd Gen Dodge Cummins 98.5-02
2
02-23-2015 08:06 AM
CumminsMan2.0
24 Valve 2nd Gen Dodge Cummins 98.5-02
1
12-11-2014 04:57 AM
W350-4x4
1st Generation Dodge Cummins 89-93
4
11-12-2014 09:35 AM