Ford Powerstroke 03-07 6.0L Discussion of 6.0 Liter Ford Powerstroke Turbo Diesels

03 f250 6.0 rough start, runs rough, shuts down

Thread Tools
 
Search this Thread
 
  #1  
Old 08-31-2015, 09:06 PM
bdbfam's Avatar
Newbie
Thread Starter
Join Date: Dec 2013
Posts: 2
Likes: 0
Received 0 Likes on 0 Posts
Default 03 f250 6.0 rough start, runs rough, shuts down

I have an issue that doesn't quite fit many other posts I have read. Drove about 100 miles, no issues, slowed for corner and had very sluggish throttle response when accelerating, 1/4 mile later engine quit. After a few minutes got it to restart but very rough and idles for less than and minute and quits. I have to wait 15 minutes or more to get it to restart, when I push the pedal it slowly goes to 2500 rpms, running rough then slowly dies. On occasion, on successful restart, it will suddenly smooth out, get full acceleration and idle correctly. I push the pedal again and it suddenly runs very rough then dies. I was chasing a problem a few months ago and replaced IPC, cam sensor, fuel filters, and checked FICM. Eventually replaced #7 injector and solved that problem so most of the suspects have been changed recently. I removed secondary fuel filter and turned key on, bowl fills OK but very slowly leaks down over 2-3minutes when key turned off. Have checked primary filter seal, fuel pump runs for about 20 seconds with key on and noticed white smoke when it finally runs. I suspect maybe a stuck open injector but can't get it to run long enough to get to town to have codes read. Any other suggestions before I drag it to town for test?
 
Related Topics
Thread
Thread Starter
Forum
Replies
Last Post
Cavnar
Diesel In Distress - Support Ticket
3
09-09-2015 07:18 PM
ish1521
Ford Powerstroke 03-07 6.0L
1
08-26-2015 08:42 PM
cjgregory
Diesel In Distress - Support Ticket
0
03-31-2015 01:45 PM
dandbmcc
Ford Powerstroke 03-07 6.0L
5
03-14-2015 11:05 PM
bizurkhate
Diesel In Distress - Support Ticket
11
11-14-2014 12:15 AM



Quick Reply: 03 f250 6.0 rough start, runs rough, shuts down



All times are GMT -5. The time now is 03:08 PM.