Ford Powerstroke 99-03 7.3L Discussion of 99-03 7.3 Liter Ford Powerstroke Turbo Diesels

oil cooler leak???????

  #1  
Old 11-09-2010, 07:01 PM
99stackedpowerstroke's Avatar
Diesel Wrench
Thread Starter
Join Date: Dec 2009
Location: southeast Iowa
Posts: 687
Received 16 Likes on 10 Posts
Default oil cooler leak???????

i have an oil leak coming from my driver side, it started last winter when it got really cold then when it warmed up it stopped like the seals swealled up, no its cold out its doing it again, it looks like its coming from the round cylinder right below my manifold, im told its the oil cooler??? this hard to fix?
 
  #2  
Old 11-09-2010, 10:12 PM
Jagsdiesel's Avatar
Diesel Bombers Sponsor- Jags Diesel
Join Date: Oct 2010
Location: Zimmerman, Mn
Posts: 175
Received 12 Likes on 12 Posts
Default

Nope its pretty easy. Remove the inner fender well. Move the steering shaft. Two bolts that hold it to the timing cover and three in the rear. Get a new cooler assebly from Ford. Make sure you lube the seals real good(two on each end, if they rip on install you'll get coolant in the oil) and you'll need a shop press to put it all together.
 
  #3  
Old 11-10-2010, 10:11 AM
99stackedpowerstroke's Avatar
Diesel Wrench
Thread Starter
Join Date: Dec 2009
Location: southeast Iowa
Posts: 687
Received 16 Likes on 10 Posts
Default

so its probably worth the 65 bucks to have it done, since the seals are gonna cost me right around 55? then pay ta have it pressed together
 
  #4  
Old 11-10-2010, 10:19 AM
CSIPSD's Avatar
Diesel Bomber
Join Date: Sep 2007
Location: Bend OR
Posts: 7,638
Received 638 Likes on 482 Posts
Default

Originally Posted by Jagsdiesel
Nope its pretty easy. Remove the inner fender well. Move the steering shaft. Two bolts that hold it to the timing cover and three in the rear. Get a new cooler assebly from Ford. Make sure you lube the seals real good(two on each end, if they rip on install you'll get coolant in the oil) and you'll need a shop press to put it all together.

You do not need to use a press to reinstall it. Just a little bit of weight and it pushs right back together...
 
  #5  
Old 11-11-2010, 10:36 AM
99stackedpowerstroke's Avatar
Diesel Wrench
Thread Starter
Join Date: Dec 2009
Location: southeast Iowa
Posts: 687
Received 16 Likes on 10 Posts
Default

so about how long does it usually take ta do this?

---AutoMerged DoublePost---

do you need any specialty tools to do this or just the average tools?
 

Last edited by 99stackedpowerstroke; 11-11-2010 at 10:36 AM. Reason: Automerged Doublepost
  #6  
Old 11-11-2010, 01:54 PM
PHPDiesel's Avatar
Sponsor
Join Date: May 2010
Posts: 327
Received 26 Likes on 20 Posts
Default

On a Super Duty, you basically only need a 10mm socket with a short extension and a drain bucket (since you'll lose a couple gallons of coolant).

There is a gasket on each end (one on the front adapter to the front cover and one from the rear adapter to the block) and 4 o-rings (two blue, two green).

On a 95-97, loosen the driver's motor mount, and use an engine hoist to lift the left side of the engine a little. The cooler goes in and comes out the same way as the SD trucks.

I've done so many that I've gotten them down to about 35 minutes start to finish.
 
  #7  
Old 11-11-2010, 05:14 PM
99stackedpowerstroke's Avatar
Diesel Wrench
Thread Starter
Join Date: Dec 2009
Location: southeast Iowa
Posts: 687
Received 16 Likes on 10 Posts
Default

so do i need to replace the gaskets too or just the seals? about how much oil will i loose? what do i use to lube the seals just fresh new oil?
 
  #8  
Old 11-11-2010, 05:38 PM
PHPDiesel's Avatar
Sponsor
Join Date: May 2010
Posts: 327
Received 26 Likes on 20 Posts
Default

You will have to do the gaskets as well. Nothing major, just aluminum plate with rubber seals around the orifices.

You have to take the oil filter off. You will lose about 2 quarts.

I use "assemblee goo" (transmission assembly gel) to lube the o-rings.



 
  #9  
Old 11-11-2010, 06:17 PM
CSIPSD's Avatar
Diesel Bomber
Join Date: Sep 2007
Location: Bend OR
Posts: 7,638
Received 638 Likes on 482 Posts
Default

Great pictures!!! That will really help people out.

I hate doing them (mine is leaking coolant a bit) because there a pain.
 
  #10  
Old 11-11-2010, 07:44 PM
99stackedpowerstroke's Avatar
Diesel Wrench
Thread Starter
Join Date: Dec 2009
Location: southeast Iowa
Posts: 687
Received 16 Likes on 10 Posts
Default

so the cooler just pulls apart and pushes back together? and yes great pictures, so just pull the inner fender the steering shaft and oil filter?
 

Last edited by 99stackedpowerstroke; 11-11-2010 at 07:50 PM.

Thread Tools
Search this Thread
Quick Reply: oil cooler leak???????



All times are GMT -5. The time now is 09:01 PM.